Since the UK disposable vape ban took effect on 1 June 2025, the Hayati Pro Ultra Plus 25000 has become one of the most talked‑about devices in the country. But what happens when your pod runs out? That's where the Hayati Pro Ultra Plus Pods come in.
If you already own the device and just need replacement pods, or if you're wondering whether this system is right for you — this is the only guide you'll need. I've been working with Hayati products since the brand launched, and I've seen the good, the bad, and the ugly when it comes to high‑puff prefilled pods. I've also spent hours on Planet of the Vapes, Reddit, and Quora, reading what real users are struggling with. The number one complaint by a mile? Burnt flavour after the first few puffs. The number one cause? Not priming the pod properly before first use.
This guide covers everything: what these pods are, how the dual‑flavour twist system actually works, a complete flavour list with tasting notes, step‑by‑step replacement and priming guides, a full troubleshooting section for common issues (burnt taste, leaking, no firing, auto‑draw failure), compatibility advice, and where to buy the best deals.
📌 Looking for a complete review of the device itself? Check out our Hayati Pro Ultra Plus 25000 Review.
What Are Hayati Pro Ultra Plus Pods?
The Hayati Pro Ultra Plus Pods are the official replacement pods for the Hayati Pro Ultra Plus 25000 kit. They are prefilled, factory‑sealed, and designed to be used until the e‑liquid runs out — then you simply replace the pod and keep using the same device. The device itself is reusable; the pod is the only consumable part.
Each pod pack contains a 2ml prefilled pod plus two 10ml auto‑refill containers. That's 22ml of 20mg nicotine salt e‑liquid in total, which the manufacturer claims delivers up to 25,000 puffs. The pod uses a 1.2Ω dual mesh coil that's built into the pod — you don't change coils separately, you change the whole pod.
🔴 Important: These pods are NOT refillable. They are factory‑sealed and designed for one‑time use. Trying to open or refill them will cause leaks, burnt flavour, and potentially damage your device.
| Hayati Pro Ultra Plus Pods — Technical Specifications | |
|---|---|
| Puff Count (claimed) | Up to 25,000 puffs (22ml total e‑liquid) |
| E‑Liquid Capacity | 2ml prefilled pod + 2 x 10ml auto‑refill containers = 22ml |
| Nicotine Strength | 20mg (2%) nicotine salt — fixed, no other strength options |
| Coil Technology | 1.2Ω dual mesh coil (built into pod) |
| Flavour System | Dual‑flavour twist‑to‑switch — two flavours per pod |
| Compatibility | Designed exclusively for the Hayati Pro Ultra Plus 25000 kit |
| Compliance | UK TPD compliant — MHRA registered |
| Price | £7.99 each or 3 for £21 (£7 per pod) |
Key Features of Hayati Pro Ultra Plus Pods
1. Mesh Coil Technology
Each pod uses a 1.2Ω dual mesh coil. Mesh coils heat e‑liquid more evenly than traditional wire coils, which means smoother flavour, no burnt spots, and consistent vapour production throughout the entire life of the pod. The coil is built into the pod, so every new pod gives you a fresh coil.
2. Prefilled and Ready to Use
These pods are prefilled and factory‑sealed. You don't need to fill them yourself, and you don't need to change coils. When the liquid runs out, you replace the entire pod. The auto‑refill system feeds liquid from the 10ml containers into the 2ml pod chamber automatically as you vape, so you never have to manually top up.
3. Dual‑Flavour System
Each pod contains two completely separate e‑liquid tanks, each feeding into its own chamber. You switch between them by lifting and rotating the mouthpiece 180 degrees. The display on the device tells you which side is active. This is not a gimmick — it genuinely works, and it means you never have to carry two devices to enjoy two different flavours.
4. Tight Compatibility
These pods are exclusively compatible with the Hayati Pro Ultra Plus 25000 kit. They will not fit the Pro Max Plus 6000, Rubik 7000, Finebar, or any other Hayati device. Always double‑check your device model before ordering.
5. TPD Compliant
All Hayati Pro Ultra Plus pods are fully UK TPD compliant and MHRA registered. The 2ml pod capacity and 20mg/ml nicotine limit are within legal UK limits, and the auto‑refill system is designed to work within TPD regulations.
💡 Expert Tip
When you insert a new pod, you'll hear a click. That's the magnetic connection securing the pod. A loose connection is one of the main reasons pods don't fire properly. Always push the pod firmly into place until it clicks — and check the display shows the correct side/status. If the display shows "no pod" or the puff counter doesn't increase, it's not seated correctly. Remove and reinsert until it clicks properly.
The Dual‑Flavour Twist System — How It Really Works
This is the defining feature of the Hayati Pro Ultra Plus system, and it's worth understanding properly.
Each pod is divided into two independent 10ml e‑liquid tanks, each connected to its own 1ml chamber inside the mouthpiece assembly. The active chamber is the one aligned with the airflow path. When you twist the mouthpiece 180 degrees, you're rotating the internal mechanism to switch which tank feeds the airflow.
The display on the device shows:
- Puff counter — total puffs across both sides
- Battery level — remaining power percentage
- Active side indicator — which flavour is currently active
This mechanism is well‑built. It doesn't feel flimsy, the flavours don't mix, and it's genuinely useful to have two flavours available without carrying extra pods or devices. Hayati has released over 30 different dual‑flavour combinations, covering everything from fruit and ice to berry medleys, tropical blends, candy profiles, and cocktail‑style flavours.
Complete Hayati Pro Ultra Plus Pods Flavour List (with Tasting Notes)
Below is the full list of all available dual‑flavour combinations for the Hayati Pro Ultra Plus pods. I've included tasting notes and categorised them by profile to help you pick the right one.
| Flavour Combo | Tasting Notes | Category |
|---|---|---|
| Blue Razz Cherry | Sharp blue raspberry with a sweet, ripe cherry finish — classic candy‑fruit crossover | Fruit & Candy |
| Fresh Mint | Clean peppermint with a subtle spearmint edge — no sweetness, just pure mint | Mint |
| Summer Dream | Light tropical fruit blend with a gentle minty breeze — like a Hawaiian cocktail | Tropical |
| Mr Blue | Dark berry blend (blackberry, blueberry, raspberry) with a soft menthol finish | Berry Ice |
| Lemon & Lime | Zesty lemon inhale, sharp lime exhale — clean, crisp, and refreshing | Citrus |
| Blueberry Raspberry | Sweet blueberry balanced with tart raspberry — smooth and consistently enjoyable | Berry |
| Strawberry Watermelon | Sweet strawberry meets juicy watermelon — light, summery, and refreshing | Fruit |
| Blue Sour Raspberry | Bold sour raspberry with a tangy kick — great for those who love a bite | Sour Berry |
| Cherry Berry | Cherry blended with mixed berries — sweet, bold, and deeply fruity | Berry |
| Blue Razz GB | Smooth GB‑style blue raspberry — cool, fruity, and easy to enjoy all day | Candy |
| H'Bubba | Sweet bubblegum flavour — playful, nostalgic, and great for a change | Candy |
| Straw' Cranberry Cherry / Cherry Ice | Strawberry cranberry cherry on one side, cool cherry ice on the other — sweet, tart, and icy | Dual Ice |
| Blackcurrant Cotton K / Blue Raspberry | Rich blackcurrant cotton candy paired with smooth blue raspberry | Candy / Fruit |
| Straw' Guvva / Dragon Berries | Strawberry guava meets exotic dragon berries — tropical and fruity | Tropical |
| Blueberry Cotton K / Raspberry Cotton K | Blueberry cotton candy on one side, raspberry cotton candy on the other — light and fluffy | Candy |
| Watermelon B'gum / Strawberry B'gum | Watermelon bubblegum meets strawberry bubblegum — sweet and playful | Candy |
| Straw' Grapefruit / Straw Dragonfruit | Strawberry grapefruit paired with strawberry dragonfruit — exotic and tropical | Tropical |
| Blueberry H'Bubba / Watermelon H'Bubba | Blueberry bubblegum on one side, watermelon bubblegum on the other — sweet and fun | Candy |
| Kiwi Banana / Straw' Banana | Tropical kiwi with banana on one side, strawberry banana on the other — smooth and fruity | Tropical |
| Grape GB / Strawberry GB | Cool GB‑style grape on one side, smooth GB‑style strawberry on the other | Candy |
| Blue Razz Pineapple / Strawberry Ice | Blue raspberry pineapple paired with strawberry ice — tropical, fruity, and icy | Fruit Ice |
| Strawberry Raspberry Ice | Strawberry and raspberry blended with cooling ice — refreshing and fruity | Fruit Ice |
| Cherry Ice / Peach Mango | Cool cherry ice on one side, tropical peach mango on the other — brilliant contrast | Dual Ice / Tropical |
| Red Razz GB / Blue Razz GB | Red raspberry GB meets blue raspberry GB — bold and very fruity | Candy |
| Watermelon Fruit Twist | Juicy watermelon blended with a fruity twist — sweet and refreshing | Fruit |
| Sour Apple / Juicy Peach | Sharp sour apple paired with sweet juicy peach — exciting and well‑balanced | Sour / Fruit |
| Fruit Twist | Multiple fruits twisted together — sweet, colourful, and enjoyable | Fruit |
| Fruit Bomb / Straw' Watermelon B'Gum | Explosive fruit bomb paired with strawberry watermelon bubblegum — bold and fun | Fruit / Candy |
| Raspberry Cola | Sweet raspberry blended with fizzy cola — nostalgic and tasty | Beverage |
| Watermelon Ice | Ripe watermelon blended with cooling ice — refreshing and sweet | Fruit Ice |
| Blue Razz GB / Lemon & Lime (New) | Sharp blue raspberry GB paired with zesty lemon and lime — exciting new combo | Candy / Citrus |
| Blue Razz Cherry / Blue Razz GB (New) | Blue razz cherry meets blue razz GB — bold and fruity | Candy |
| Lemon & Lime / Summer Dream (New) | Zesty citrus paired with tropical Summer Dream — fresh and dreamy | Citrus / Tropical |
| Straw' Cranberry Cherry / Strawberry Raspberry Ice (New) | Strawberry cranberry cherry paired with strawberry raspberry ice — exciting new dual flavour | Fruit Ice |
| Blueberry Raspberry / Mr Blue (New) | Fruity blueberry raspberry paired with smooth Mr Blue — brilliant new combo | Berry |
📌 All flavours use 20mg nic salt and come prefilled in the dual‑flavour pod system. Replacement pods are available separately.
How to Replace Hayati Pro Ultra Plus Pods — Step‑by‑Step Guide
Replacing a pod on the Hayati Pro Ultra Plus is simple and takes less than a minute. Here's how to do it correctly:
- Remove the old pod: Gently pull the pod assembly out of the device. Don't yank it — it should come out smoothly.
- Inspect the device: Check the contacts inside the device for any liquid residue or debris. If there's any, gently wipe with a cotton bud.
- Prepare the new pod: Take the new pod out of its packaging. Remove any silicone bungs or protective seals from the refill containers and the pod contacts.
- Insert the pod: Align the pod with the device and push it in firmly until you feel and hear a click. The magnetic connection should secure it.
- Check the display: The screen should show the puff counter and indicate which side is active. If it says "no pod" or doesn't respond, the pod isn't seated properly — remove and reinsert.
- Prime the pod (crucial — see below): Let the pod sit for 5‑10 minutes before taking your first puff. This allows the mesh coil to fully saturate with e‑liquid.
💡 Expert Tip: Priming Your Pod (The Most Important Step)
Priming is the single most important step for getting good flavour and preventing burnt taste. After inserting a new pod, wait 5‑10 minutes before taking your first puff. This allows the mesh coil to fully saturate with e‑liquid. If you skip this, you risk burning the coil on the very first hit — and that burnt taste never goes away, even after a few puffs. The coil damage is permanent. I've seen this happen to countless vapers who just didn't know. Waiting 10 minutes is all it takes to avoid a ruined pod.
How to Prime a Hayati Pro Ultra Plus Pod — The Right Way
Priming is simple, but doing it correctly makes all the difference:
- Assemble the pod with the two 10ml refill containers.
- Click the assembled pod into the device.
- Let the pod sit for 5‑10 minutes with the device upright.
- Take a few short, gentle puffs without firing (just pull air through the mouthpiece). This helps draw e‑liquid into the coil.
- After 5‑10 minutes, take your first proper puff. Start with a short, gentle draw — don't chain‑vape right away.
- The flavour should be clean and full. If it tastes burnt or weak, you may have a faulty pod or didn't wait long enough.
Troubleshooting Common Hayati Pro Ultra Plus Pod Issues
Based on hundreds of user reports from forums like Planet of the Vapes and Reddit, these are the most common issues and their solutions:
❌ Burnt Taste
Cause: Coil not primed properly, chain‑vaping too fast, or faulty pod.
Solution: If it's a new pod, it's likely because you didn't prime it — the coil is already damaged and won't recover. Replace with a new pod and prime properly this time. If it's a pod you've been using, try slowing down your draws to let the auto‑refill system catch up. If the problem persists, replace the pod.
❌ Leaking from Airflow Holes
Cause: Stored in hot conditions, pod not fully inserted, or faulty seal.
Solution: Remove the pod and check it's fully inserted. If it's loose, push it firmly until it clicks. Avoid leaving the device in direct sunlight or in a hot car — heat thins e‑liquid and causes leaks. If the pod is faulty, replace it.
❌ Pod Not Firing / No Vapour
Cause: Pod not connected properly, dirty contacts, or dead battery.
Solution: Remove the pod and reinsert firmly. Clean the contacts with a cotton bud. Check the battery level on the display — if it's low, recharge. If none of that works, try a fresh pod.
❌ Auto‑Draw Not Working
Cause: Mouthpiece blocked, moisture in the auto‑draw sensor, or pod not seated properly.
Solution: Wipe the mouthpiece and the area around it with a dry cloth. If moisture has gotten into the sensor, leave the device in a warm, dry place for a few hours. If the problem persists, try a fresh pod.
❌ Flavour Drops Off Before Pod Is Empty
Cause: Chain‑vaping faster than the refill system can keep up.
Solution: Slow down between draws. The auto‑refill system needs a few seconds to feed liquid from the 10ml containers into the 2ml chamber. If you're taking long, back‑to‑back draws, the coil can run dry mid‑puff and start to burn. Give it a moment between puffs.
❌ Pod Doesn't Click In Properly
Cause: Debris in the chamber or misalignment.
Solution: Clean the chamber area with a dry cotton bud. Check the pod for any visible damage. Align it carefully and push firmly until you feel the click. If it still doesn't click, the pod may be faulty — try a fresh one.
How Long Does a Hayati Pro Ultra Plus Pod Actually Last?
The claimed number is 25,000 puffs, but real‑world usage varies significantly. Based on customer feedback and my own testing:
- Light user (600‑1000 puffs/day): 25‑40 days per pod
- Moderate user (1200‑1500/day): 16‑21 days
- Heavy user (1800‑2500/day): 10‑14 days
The key variable is draw length. Longer draws use more liquid per puff, so the puff count will be lower. The 25,000 figure is based on short, standard MTL draws. If you take long, slow draws, you'll get fewer puffs. But the total liquid capacity (22ml) is fixed — you're always getting the same amount of e‑liquid per pod.
Compatibility — Which Devices Work With These Pods?
These pods are ONLY compatible with the Hayati Pro Ultra Plus 25000 kit. They will NOT fit:
- ❌ Hayati Pro Max Plus 6000
- ❌ Hayati Rubik 7000
- ❌ Hayati Finebar
- ❌ Hayati Mini Ultra 1500
- ❌ Any other Hayati device
Always check the name printed on your device before ordering. The pod design is specific to the Pro Ultra Plus 25000, and using the wrong pod can cause leaking, poor performance, or damage to the device. If you're unsure, check the Hayati Pro Ultra Plus product page for compatibility details.
TPD Compliance — Are These Pods Legal in the UK?
Yes. All Hayati Pro Ultra Plus pods are fully UK TPD compliant and MHRA registered. The 2ml pod capacity and 20mg/ml nicotine limit are within UK legal limits. The auto‑refill system uses 10ml containers, which are also compliant. Every pod pack includes QR codes that link directly to the MHRA listing for verification.
Where to Buy Hayati Pro Ultra Plus Pods in the UK
You can buy the official Hayati Pro Ultra Plus replacement pods at Vape Online Store for £7.99 each, reduced from £8.99. The best deal is the 3 for £21 multi‑buy offer, which works out to just £7 per pod.
The Hayati Pro Ultra Plus 25000 kit is also available at £11.99 (saving £9.00) or 3 for £33 (£11 per kit).
Shop Hayati Pro Ultra Plus Pods
Hayati Pro Ultra Plus Replacement Pods — 22ml of 20mg nic salt, dual‑flavour twist system, 1.2Ω dual mesh coil. TPD compliant. Over 30 flavour combinations available.
💰 Multi‑buy deal: Pods are 3 for £21 (£7 each). Kits are 3 for £33 (£11 each). Free next‑day delivery on orders over £40. 4.6/5 Trustpilot rating (7,300+ reviews).
FAQs – Frequently Asked Questions
Q. How many puffs does a Hayati Pro Ultra Plus pod actually give?
The claimed number is 25,000 puffs based on 22ml of e‑liquid. Real‑world usage varies: heavy vapers (1,800‑2,500 puffs/day) get 10‑14 days; moderate vapers (1,200‑1,500/day) get 16‑21 days; light vapers (600‑1,000/day) get 25‑40 days. Draw length is the main variable — longer draws reduce puff count.
Q. Are Hayati Pro Ultra Plus pods refillable?
No. The pods are prefilled, factory‑sealed, and designed for one‑time use. Attempting to open or refill them will cause leaks, burnt flavour, and may damage your device. When the liquid runs out, replace the entire pod.
Q. Which devices are Hayati Pro Ultra Plus pods compatible with?
These pods are exclusively compatible with the Hayati Pro Ultra Plus 25000 kit. They will NOT fit the Pro Max Plus 6000, Rubik 7000, Finebar, or any other Hayati device. Always check your device model before ordering.
Q. Why does my Hayati pod taste burnt after the first few puffs?
This is almost always because you didn't prime the pod properly before first use. The mesh coil needs 5‑10 minutes to fully saturate with e‑liquid. If you took a puff immediately after inserting the pod, the coil may already be burnt. The damage is permanent — you'll need to replace the pod and prime it properly this time.
Q. My pod is leaking — what should I do?
Leaking is rare with genuine Hayati pods. Check the pod is fully inserted and clicked into place. Avoid storing the device in direct sunlight or hot conditions — heat thins e‑liquid and causes leaks. If the problem persists, the pod may be faulty and needs replacing.
Q. How do I know when the pod is empty?
Flavour will drop off noticeably, vapour production will decrease, and the transparent windows on the pod will show empty chambers. Some devices also show "low liquid" warnings on the screen. When flavour weakens, it's time to replace the pod.
Q. What nicotine strength do these pods use?
20mg (2%) nicotine salt — the legal maximum in the UK. There is no 10mg or 0mg option for this device; the pods come prefilled and sealed at 20mg.
Q. Are Hayati Pro Ultra Plus pods TPD compliant?
Yes. Every pod is fully UK TPD compliant and MHRA registered. The 2ml pod capacity and 20mg/ml nicotine limit are within legal limits. The QR code on the packaging links directly to the MHRA listing.
Q. How long do Hayati Pro Ultra Plus pods last in days?
Light users get 25‑40 days per pod, moderate users get 16‑21 days, heavy users get 10‑14 days. The battery (850mAh) is designed to outlast the liquid in the pod, so you won't run out of battery before the liquid is finished.
Q. Can I use Hayati Pro Ultra Plus pods with a different brand device?
No. These pods are specifically designed for the Hayati Pro Ultra Plus 25000 kit. They are not cross‑compatible with any other brand or model. Using them with a different device will not work and may cause damage.
Q. Why is the flavour weak on my Hayati Pro Ultra Plus pod?
Weak flavour is usually caused by one of two things: (1) the pod wasn't primed properly, so the coil isn't fully saturated, or (2) you're chain‑vaping faster than the auto‑refill system can keep up. Slow down between draws and ensure you wait 5‑10 minutes after inserting a new pod before first use.
Q. How do I switch flavours on the Hayati Pro Ultra Plus pod?
Simply lift and rotate the mouthpiece 180 degrees until it clicks. The display on the device will show which side is active. This lets you switch between the two flavours instantly without changing the pod.
Q. Are Hayati Pro Ultra Plus pods available in 10ml?
No. Each pod contains a 2ml prefilled pod plus two 10ml auto‑refill containers, totalling 22ml of e‑liquid. The 10ml containers are for auto‑refill, not for direct vaping. The pod itself is a 2ml prefilled chamber.
Final Verdict — Are Hayati Pro Ultra Plus Pods Worth It?
The Hayati Pro Ultra Plus pods are one of the most well‑designed replacement pod systems on the UK market. The dual‑flavour twist system is genuinely useful, the mesh coil delivers consistent flavour, and the 22ml total capacity means fewer pod changes — a major advantage for heavy vapers.
For vapers coming from disposables, the transition is seamless: the pods are prefilled, the flavour profiles match familiar disposable profiles, and the device is draw‑activated with no buttons to learn. For experienced vapers, the dual‑flavour system offers a level of variety that most high‑capacity kits simply don't provide.
The key to getting the best experience is proper priming — wait 5‑10 minutes after inserting a new pod before taking your first puff. This single step will save you countless burnt pods and wasted money.
If you're looking for a high‑capacity prefilled pod system that delivers flavour, variety, and reliability, the Hayati Pro Ultra Plus pods are an excellent choice.
And if you're still comparing options, check out our complete review of the Hayati Pro Ultra Plus kit or our Hayati Pro Max Plus pods guide for a comparison.
